IJSRSET calls volunteers interested to contribute towards the scientific development in the field of Science, Engineering and Technology

Home > IJSRSET1522113                                                     


Pre-treatment Methods for Seawater Desalination and Industrial Wastewater Treatment: A Brief review

Authors(3):

Ali Hashlamon, Akil Ahmad, Lau Choon hong
  • Abstract
  • Authors
  • Keywords
  • References
  • Details
Feed water that need to be pre-treated before using methods such as, microfiltration, Ultrafiltration, nanofiltration and reverse osmosis is characterized by containing turbidity, bacterial content and total dissolved solid which causes fouling and scaling in membrane performance. Thus, it is necessary to develop a method which is cost effective. Pre-treatment has been shown as a good method to enhance the performance and reducing the cost of replacement for membrane of the RO/NF as it helps to remove turbidity, bacteria and TDS (Total dissolve solid), COD and Colour. In this paper, a brief review on the pretreatment in different industry will be clarified such as pretreatment of seawater, and wastewater treatment. Basically, methods of pretreatment can be categorized as coagulation, flocculation, sedimentation, microfiltration, ultrafiltration, ozonation and etc. Therefore, this review can provide a better alternative in solving the membrane fouling and scaling problem.

Ali Hashlamon, Akil Ahmad, Lau Choon hong

Pre-treatment, Sea Water, Industrial Wastewater, Fouling

  1. Bonnelye, Véronique, Sanz, Miguel Angel, Durand, Jean-Pierre, Plasse, Ludovic, Gueguen, Frédéric & Mazounie, Pierre. 2004. Reverse osmosis on open intake seawater: pre-treatment strategy. Desalination 167(0):191-200.
  2. van Paassen, Jacques A. M., Kruithof, Joop C., Bakker, Simon M. & Kegel, Frank Schoonenberg. 1998. Integrated multi-objective membrane systems for surface water treatment: pre-treatment of nanofiltration by riverbank filtration and conventional ground water treatment. Desalination 118(1-3):239-248.
  3. Mosqueda-Jimenez, Daniella B. & Huck, Peter M. 2009. Effect of biofiltration as pretreatment on the fouling of nanofiltration membranes. Desalination 245(1-3):60-72.
  4.  Delphos, P. J., & Wesner, G. M. (2005). Mixing, Coagulation, and Flocculation. In E. E. Baruth, Water Treatment Plant Design (pp. 107-131). New York: McGraw-Hill.
  5. Davis, M. L. (2010). Water and Waste Water Engineering, Design Principles and Practice. New York: McGraw-Hill.
  6. Shammas, N. K. (2005). Coagulation and Flocculation. In L. K. Wang, Y.-T. Hung, & N. K. Shammas, Physicochemical Treatment Processes (pp. 103-139). New Jersey: Humana Press Inc.
  7. Koohestanian, A., Hosseini, M., & Abbasian, Z. (2008). The Separation Method for Removing of Colloidal Particles from Raw Water. American-Eurasian J. Agric. & Environ. Sci., 266-273.
  8. Gabelich, Christopher J., Chen, Wei R., Yun, Tae I., Coffey, Bradley M. & “Mel” Suffet, I. H. 2005. The role of dissolved aluminum in silica chemistry for membrane processes. Desalination 180(1-3):307-319.
  9. Kim, E.-S., Liu, Y., & Gamal El-Din, M. (2011). The effects of pretreatment on nanofiltration and reverse osmosis membrane filtration for desalination of oil sands process-affected water. Separation and Purification Technology, 418-428.
  10. Kabsch-Korbutowicz, M. (2006 ). Removal of natural organic matter from water by in-line coagulation/ultrafiltration process. Desalination, 421-423.
  11. Gabelich, Christopher J., Ishida, Kenneth P., Gerringer, Fredrick W., Evangelista, Ray, Kalyan, Minhaal & Suffet, I. H. “Mel”. 2006. Control of residual aluminum from conventional treatment to improve reverse osmosis performance. Desalination 190(1-3):147-160.
  12. López-Ram??rez, J. A., Sahuquillo, S., Sales, D. & Quiroga, J. M. 2003. Pre-treatment optimisation studies for secondary effluent reclamation with reverse osmosis. Water Research 37(5):1177-1184.
  13. Wan Ngah, W. S., & Hanafiah, M. K. (2008). Removal of heavy metal ions from wastewater by chemically modified plant wastes as adsorbents: A review. Bioresource Technology, 3935-3948.
  14. Lee, Lai Yoke, Ng, How Yong, Ong, Say Leong, Hu, Jiang Yong, Tao, Guihe, Kekre, Kiran, Viswanath, Balakrishnan, Lay, Winson & Seah, Harry. 2009. Ozone-biological activated carbon as a pretreatment process for reverse osmosis brine treatment and recovery. Water Research 43(16):3948-3955.
  15. Gao, W., Liang, H., Ma, J., Han, M., Chen, Z.l., Han, Z.s., et al. (2011). Membrane fouling control in ultrafiltration technology for drinking water production: A review. Desalination, 1-8.
  16. Campinas, M., & Rosa, M. J. (2010). Assessing PAC contribution to the NOM fouling control in PAC/UF systems. Water Research , 1 6 3 6 - 1 6 4 4.
  17. Lee, S. j., Choo, k. h., & Lee, C. h. (2000). Conjunctive use of ultrafiltration with powdered activated carbon adsorption for removal of synthetic and natural organic matter. J. Ind. Eng. Chem, 357-364.
  18. Matilainen, Anu, Vieno, Niina & Tuhkanen, Tuula. 2006. Efficiency of the activated carbon filtration in the natural organic matter removal. Environment International 32(3):324-331.
  19. Vigneswaran, S., Ngo, H. H., Chaudhary, D. S., & Hung, Y. T. (2005). Physicochemical Treatment Processes for Water Reuse. In L. K. Wang, Y.-T. Hung, & N. K. Shammas, Physicochemical Treatment Processes (pp. 635-676). New Jersy: Human Press.
  20. Sarayu, K., Swaminathan, K., & Sandhya, S. (2007). Assessment of degradation of eight commercial reactive azo dyes individually and in mixture in aqueous solution by ozonation. Dyes and Pigments , 362-368.
  21. Tehrani-Bagha, A. R., Mahmoodi, N. M., & Menger, F. M. (2010). Degradation of a persistent organic dye from colored textile wastewater by ozonation. Desalination , 34-38.
  22. Sangave, P. C., Gogate, P. R., & Pandit, A. B. (2007). Combination of ozonation with conventional aerobic oxidation for distillery wastewater treatment. Chemosphere, 32-41.
  23. Wu, C.H., Kuo, C.Y., & Changc, C.L. (2008). Homogeneous catalytic ozonation of C.I. Reactive Red 2 by metallic ions in a bubble column reactor. Journal of Hazardous Materials , 748-755.
  24. Prihasto, Noka, Liu, Qi-Feng & Kim, Seung-Hyun. 2009. Pre-treatment strategies for seawater desalination by reverse osmosis system. Desalination 249(1):308-316.
  25. Jeong, Seongpil, Park, Yonghea, Lee, Seockheon, Kim, Janghong, Lee, Kwanhyung, Lee, Jeawoo & Chon, Hyo-Taek. 2011. Pre-treatment of SWRO pilot plant for desalination using submerged MF membrane process: Trouble shooting and optimization. Desalination 279(1-3):86-95.
  26. Elguera, A. Múñoz & Pérez Báez, S. O. 2005. Development of the most adequate pre-treatment for high capacity seawater desalination plants with open intake. Desalination 184(1-3):173-183.
  27. Vial, D., Doussau, G. & Galindo, R. 2003. Comparison of three pilot studies using Microza® membranes for Mediterranean seawater pre-treatment. Desalination 156(1-3):43-50.
  28. Brehant, A., Bonnelye, V. & Perez, M. 2002. Comparison of MF/UF pretreatment with conventional filtration prior to RO membranes for surface seawater desalination. Desalination 144(1-3):353-360.
  29. Lorain, Olivier, Hersant, Berengère, Persin, Françoise, Grasmick, Alain, Brunard, Nathalie & Espenan, Jean Michel. 2007. Ultrafiltration membrane pre-treatment benefits for reverse osmosis process in seawater desalting. Quantification in terms of capital investment cost and operating cost reduction. Desalination 203(1-3):277-285.
  30. Vial, D. & Doussau, G. 2003. The use of microfiltration membranes for seawater pre-treatment prior to reverse osmosis membranes. Desalination 153(1-3):141-147.
  31. Johir, A. H., Khorshed, C., Vigneswaran, S. & Shon, H. K. 2009. In-line flocculation-filtration as pre-treatment to reverse osmosis desalination. Desalination 247(1-3):85-93.
  32. van Hoof, S. C. J. M., Minnery, J. G. & Mack, B. 2001. Dead-end ultrafiltration as alternative pre-treatment to reverse osmosis in seawater desalination: a case study. Desalination 139(1-3):161-168.
  33. Ye, Yun, Sim, Lee Nuang, Herulah, Bram, Chen, Vicki & Fane, A. G. 2010. Effects of operating conditions on submerged hollow fibre membrane systems used as pre-treatment for seawater reverse osmosis. Journal of Membrane Science 365(1-2):78-88.
  34. Byung Soo, Jang, Ha Young, Cho, Jaeweon, Lee, Sungyun, Lee, Eunkyung, Kim, In S., Hwang, Tae Mun & Kang, Joon-Wun. 2009. Effect of ozone on microfiltration as a pretreatment of seawater reverse osmosis. Desalination 238(1-3):90-97.
  35. Hilal, Nidal, Mohammad, A. Wahab, Atkin, Brian & Darwish, Naif A. 2003. Using atomic force microscopy towards improvement in nanofiltration membranes properties for desalination pre-treatment: a review. Desalination 157(1-3):137-144.
  36. Lee, J. J., Johir, M. A. H., Chinu, K. H., Shon, H. K., Vigneswaran, S., Kandasamy, J., Kim, C. W. & Shaw, K. 2010. Novel pre-treatment method for seawater reverse osmosis: Fibre media filtration. Desalination 250(2):557-561.
  37. Schneider, R. P., Ferreira, L. M., Binder, P., Bejarano, E. M., Góes, K. P., Slongo, E., Machado, C. R. & Rosa, G. M. Z. 2005. Dynamics of organic carbon and of bacterial populations in a conventional pretreatment train of a reverse osmosis unit experiencing severe biofouling. Journal of Membrane Science 266(1-2):18-29.
  38. Bes-Piá, A., Iborra-Clar, M. I., Iborra-Clar, A., Mendoza-Roca, J. A., Cuartas-Uribe, B. & Alcaina-Miranda, M. I. 2005. Nanofiltration of textile industry wastewater using a physicochemical process as a pre-treatment. Desalination 178(1-3):343-349.
  39. De Gisi, Sabino, Galasso, Maurizio & De Feo, Giovanni. 2009. Treatment of tannery wastewater through the combination of a conventional activated sludge process and reverse osmosis with a plane membrane. Desalination 249(1):337-342.
  40. Baccella, S., Cerichelli, G., Chiarini, M., Ercole, C., Fantauzzi, E., Lepidi, A., Toro, L. & Vegliò, F. 2000. Biological treatment of alkaline industrial waste waters. Process Biochemistry 35(6):595-602.
  41. Zahrim, A. Y., Tizaoui, C. & Hilal, N. 2011. Coagulation with polymers for nanofiltration pre-treatment of highly concentrated dyes: A review. Desalination 266(1-3):1-16.
  42. Golob, Vera, Vinder, Aleksandra & Simoni?, Marjana. 2005. Efficiency of the coagulation/flocculation method for the treatment of dyebath effluents. Dyes and Pigments 67(2):93-97.
  43. Suksaroj, C., Héran, M., Allègre, C. & Persin, F. 2005. Treatment of textile plant effluent by nanofiltration and/or reverse osmosis for water reuse. Desalination 178(1-3):333-341.
  44. Georgiou, D., Aivazidis, A., Hatiras, J. & Gimouhopoulos, K. 2003. Treatment of cotton textile wastewater using lime and ferrous sulfate. Water Research 37(9):2248-2250.
  45. Lin, Sheng H. & Chen, Ming L. 1997. Treatment of textile wastewater by chemical methods for reuse. Water Research 31(4):868-876.
  46. Capar, Goksen, Yetis, Ulku & Yilmaz, Levent. 2007. The most effective pre-treatment to nanofiltration for the recovery of print dyeing wastewaters. Desalination 212(1-3):103-113.
  47. Benito-Alcázar, C., Vincent-Vela, M. C., Gozálvez-Zafrilla, J. M. & Lora-García, J. 2010. Study of different pretreatments for reverse osmosis reclamation of a petrochemical secondary effluent. Journal of Hazardous Materials 178(1-3):883-889.
  48. Kang, Suck-Ki & Choo, Kwang-Ho. 2003. Use of MF and UF membranes for reclamation of glass industry wastewater containing colloidal clay and glass particles. Journal of Membrane Science 223(1-2):89-103.
  49. Bes-Pía, A., Iborra-Clar, A., Mendoza-Roca, J. A., Iborra-Clar, M. I. & Alcaina-Miranda, M. I. 2004. Nanofiltration of biologically treated textile effluents using ozone as a pre-treatment. Desalination 167(0):387-392.
  50. Dialynas, Emmanuel, Mantzavinos, Dionissios & Diamadopoulos, Evan. 2008. Advanced treatment of the reverse osmosis concentrate produced during reclamation of municipal wastewater. Water Research 42(18):4603-4608.
  51. Kruithof, Joop C., Schippers, Jan C., Kamp, Peer C., Folmer, H. C. & Hofman, Jan A. M. H. 1998. Integrated multi-objective membrane systems for surface water treatment: pretreatment of reverse osmosis by conventional treatment and ultrafiltration. Desalination 117(1-3):37-48.
  52. Abdel-Jawad, M., Al-Shammari, S. & Al-Sulaimi, J. 2002. Non-conventional treatment of treated municipal wastewater for reverse osmosis. Desalination 142(1):11-18.

Publication Details

Published in : Volume 1 | Issue 2 | March-April - 2015
Date of Publication Print ISSN Online ISSN
2015-04-04 2395-1990 2394-4099
Page(s) Manuscript Number   Publisher
422-428 IJSRSET1522113   Technoscience Academy

Cite This Article

Ali Hashlamon, Akil Ahmad, Lau Choon hong, "Pre-treatment Methods for Seawater Desalination and Industrial Wastewater Treatment: A Brief review", International Journal of Scientific Research in Science, Engineering and Technology(IJSRSET), Print ISSN : 2395-1990, Online ISSN : 2394-4099, Volume 1, Issue 2, pp.422-428, March-April-2015.
URL : http://ijsrset.com/IJSRSET1522113.php

IJSRSET Xplore

Subscribe

Conferences

National Conference on Advances in Mechanical Engineering 2017(NCAME 2017)

National Conference on Emerging Trends in Civil Engineering 2017( NCETCE 2017)